All You Need To Know About Removing Solids From Wastewater Using Imhoff Tanks
- Date: 2007-08-17 - Word Count: 582
Share This!
Recycling and reuse of wastewater will do away with the need of using fresh water. The extent to which the processes involved in wastewater treatment are cost effective and easy to follow will act as an impetus. Hence discussing about the processes involved in wastewater treatment and their relative merits and demerits becomes pertinent.
Like Sedimentation tanks, Septic tanks (Imhoff tanks) can play a major role in the process of removing solids from wastewater.
Designed by Karl Imhoff of Germany, an Imhoff tank is an improved septic tank in which the incoming sewage or influent is not allowed to get mixed up with the sludge
produced. Also, the outgoing sewage or effluent is not allowed to carry with it any large amount of the suspended matter as in the case of a septic tank.
**Construction and operational features**
It is a double chamber tank, the upper chamber is called the sedimentation tank or flowing-through chamber, through which sewage flows at a very low velocity; the lower chamber is the digestion chamber in which anaerobic or septic decomposition occurs.
Solids of the sewage settle to the bottom of the sedimentation chamber through the sloping bottom walls (slope 5 vertical to 4 horizontal). They are made to fall in
the digestion chamber through an entrance slot at the lowest point of the sedimentation chamber. The slot is trapped or overlapped in such a way that the gases generated in the
digestion chamber cannot enter the sedimentation chamber.
A gas vent, also called scum chamber is provided with the digestion chamber to take care of the gases escaping to the surface. The chief gas is methane (CH ) having a
considerable fuel value and may, therefore, be separately collected for use. In order to prevent particles of sludge or scum from penetrating into the sedimentation chamber, the
sludge and scum must be maintained at a distance of at least 45 cm below and above the slots respectively. The free or clear zone is called neutral zone.
The digestion chamber is made up of two or three inverted cones called hoppers with sides sloping (1 : 1) so as to concentrate the sludge at the bottom of the hopper. The
sludge is removed periodically through sludge-pipe, the flow being under a hydrostatic pressure of 1.2 to 1.8 m. All the sludge is not removed, only the lower layers which are
completely decomposed are withdrawn, leaving some sludge to keep the tank seeded with anaerobic bacteria.
To permit uniform distribution of settled solids throughout the length of the digestion chamber, so as to utilize the storage capacity in the greatest measure, arrangements for
reversing the direction of flow through the tanks are commonly made.
**Merits**
Imhoff tanks combine the advantages of both the septic and sedimentation tanks and, as such find use in case of small treatment plants requiring only preliminary treatment. They
have better economy and give good results without skilled attention with minimum problems of sludge disposal.
**Demerits**
(i) Greater depth means greater costs and especially where excavation is to be done in quick sands or solids rock, they become uneconomical. (ii) Unsuitable to acidic wastewater exists. (iii) There's no adequate control over their operation. This makes them unsuitable for use in large treatment plants where separate sludge digestion tanks are preferred.
The above is an excerpt from the free newsletter on "All About Wastewater Treatment"
published by Geostar Publishing & Services LLC.
To subscribe to the newsletter, click on the link below:
http://www.allaboutwastewatertreatment.com/inst.php
"Everything you really need to know about Wastewater treatment, all in one place!"
From the Desk of Richard Runion and TEAM
Here's to a happier experience!
Richard Runion
6423, Woodbine Court,
St. Louis, Missouri,
63109, USA
http://www.allaboutwastewatertreatment.com/inst.php
http://allaboutwastewatertreatment.opt-in-newsletter.info/wastewater.php
Like Sedimentation tanks, Septic tanks (Imhoff tanks) can play a major role in the process of removing solids from wastewater.
Designed by Karl Imhoff of Germany, an Imhoff tank is an improved septic tank in which the incoming sewage or influent is not allowed to get mixed up with the sludge
produced. Also, the outgoing sewage or effluent is not allowed to carry with it any large amount of the suspended matter as in the case of a septic tank.
**Construction and operational features**
It is a double chamber tank, the upper chamber is called the sedimentation tank or flowing-through chamber, through which sewage flows at a very low velocity; the lower chamber is the digestion chamber in which anaerobic or septic decomposition occurs.
Solids of the sewage settle to the bottom of the sedimentation chamber through the sloping bottom walls (slope 5 vertical to 4 horizontal). They are made to fall in
the digestion chamber through an entrance slot at the lowest point of the sedimentation chamber. The slot is trapped or overlapped in such a way that the gases generated in the
digestion chamber cannot enter the sedimentation chamber.
A gas vent, also called scum chamber is provided with the digestion chamber to take care of the gases escaping to the surface. The chief gas is methane (CH ) having a
considerable fuel value and may, therefore, be separately collected for use. In order to prevent particles of sludge or scum from penetrating into the sedimentation chamber, the
sludge and scum must be maintained at a distance of at least 45 cm below and above the slots respectively. The free or clear zone is called neutral zone.
The digestion chamber is made up of two or three inverted cones called hoppers with sides sloping (1 : 1) so as to concentrate the sludge at the bottom of the hopper. The
sludge is removed periodically through sludge-pipe, the flow being under a hydrostatic pressure of 1.2 to 1.8 m. All the sludge is not removed, only the lower layers which are
completely decomposed are withdrawn, leaving some sludge to keep the tank seeded with anaerobic bacteria.
To permit uniform distribution of settled solids throughout the length of the digestion chamber, so as to utilize the storage capacity in the greatest measure, arrangements for
reversing the direction of flow through the tanks are commonly made.
**Merits**
Imhoff tanks combine the advantages of both the septic and sedimentation tanks and, as such find use in case of small treatment plants requiring only preliminary treatment. They
have better economy and give good results without skilled attention with minimum problems of sludge disposal.
**Demerits**
(i) Greater depth means greater costs and especially where excavation is to be done in quick sands or solids rock, they become uneconomical. (ii) Unsuitable to acidic wastewater exists. (iii) There's no adequate control over their operation. This makes them unsuitable for use in large treatment plants where separate sludge digestion tanks are preferred.
The above is an excerpt from the free newsletter on "All About Wastewater Treatment"
published by Geostar Publishing & Services LLC.
To subscribe to the newsletter, click on the link below:
http://www.allaboutwastewatertreatment.com/inst.php
"Everything you really need to know about Wastewater treatment, all in one place!"
From the Desk of Richard Runion and TEAM
Here's to a happier experience!
Richard Runion
6423, Woodbine Court,
St. Louis, Missouri,
63109, USA
http://www.allaboutwastewatertreatment.com/inst.php
http://allaboutwastewatertreatment.opt-in-newsletter.info/wastewater.php
Related Tags: environment, freshwater, wastewater, wastewatertreatment plant, watertreatment processes, methods of cleaning water, waterrecycling, imhofftanks
Your Article Search Directory : Find in Articles
Recent articles in this category:
- How Hypnotherapy Can be Used on Children
Today Hypnosis can be termed as a branch of medicine which is quite unique, whereas in the past this - Confidence Workshops For Children
Every parent wants their children to be confident, happy, highly motivated and enthusiastic in order - Inspiring Children Using NLP
Neuro-Linguistic Programming (NLP) is one of the most successful therapies in psychology today. Init - Writing Term Papers
Students often tend to put off a written assignment, considering it to be a chore too formidable to - Naming In Term Paper
Give a descriptive name to each of your concept in the paper. Adhere using terms like "our approach" - Introduction Section of a Research Paper
Your introductions should not exceed more than two pages (typed, double spaced). See again the examp - Getting a Feedback of Your Term Paper is Important!
Get the feedback of your work! Finish your paper, having written it well in advance, so that you hav - The 1950's - Was Life Better?
Iconic TV shows like I Love Lucy, Dennis the Menace and My Three Sons seem to indicate that the 1950 - Online Classroom Systems Makes Home Schooling Even More Attractive
In the past it went without saying that you would send your kids to public schools. With public scho - 8 Helpful Tips For Surviving Military Basic Training
Getting through military basic training takes a lot perseverance. During this training it is best to
Most viewed articles in this category:
- Culinary Cooking Schools and What They Teach
Culinary cooking schools prepare you for a job in the culinary industry by providing you with the kn - How To Learn Spanish Quickly Without Moving To Spain
Learning Spanish is a popular pastime, as well as a serious goal for many individuals. Whether it's - How To Improve Your Life With An Accredited Online College Degree
With the information super highway raring full steam ahead, quality accredited online college degree - Online Bachelor Degree Programs Go Mainstream
The Internet has seen an explosion in online bachelor degree programs in the last five to ten years - Online Degree Program Just A Click Away
You want to go shopping, but your car is low on gas. You want to know your account balance, but do n - Online Paralegal Degree Will Open Doors
An online paralegal degree may offer the possibility of improving your chances in the legal professi - What West Point Military School Looks For In A Candidate
West Point is looking for well rounded young men and women who are good students, good athletes, and - The Importance of Effective Accounting Programs
In the past, small businesses like mom and pop stores were not required to maintain any sort of acco - California Schools Educators Retirement System And Lionstone Group Create Investment Fund
The California State Teachers' Retirement System (CSTRS) is the second largest public pension fund i - A Taste of China - Seattle Schools New Guest Teacher Shares Language and Culture of Her Native Hom
The Seattle schools have a new "guest" teacher. Zhu Dan arrived in the Seattle schools in January